Whirlpool AMD 010 Installation Manual download pdf (Page 21)

OUTDOOR UNIT INSTALLATION

1. Install Drain Port and Drain Hose (for heat-

pump model only)

The condensate drains from the outdoor unit when

the unit operates in heating mode. In order not to

disturb your neighbours and protect the

environment, install a drain port and a drain hose to

direct the condensate water. Just install the drain

port and rubber washer on the chassis of the

outdoor unit, then connect a drain hose to the port

as shown in the figure on the right .

2. Install and Fix Outdoor Unit

Fix with bolts and nuts tightly on a flat and strong

floor.

If installed on the wall or roof, make sure to fix the

supporter well to prevent it from shaking due to serious vibration or strong wind.

3. Outdoor Unit Piping Connection

• Remove the valve caps from the 2-way and 3-way valve.

• Connect the pipes to the 2-way and 3-way valves separately according to the required torque.

4. Outdoor Unit Cable Connection (see previous page)

Air purging

Air containing moisture remaining in the refrigeration cycle may cause a malfunction on the compressor.

After connecting the indoor and outdoor units, evacuate air and moisture from refrigerant cycle using a

vacuum pump, as shown below.

Note: Because the system pressure is high and also to protect the environment, be sure not to discharge

the refrigerant to the air directly.

Washer

Drain port

Drain hose

(prepare by user)

Vacuum pump

Indoor unit

Refrigerant flow direction

3-way valve

Service port

(2) Turn

(8) Tighten

(7) Turn to fully

open the valve

Valve cap

(1) Turn

(8) Tighten

2-way valve

(6) Open 1/4 turn

(7) Turn to fully open the valve

(1) Turn

Valve cap

(8) Tighten

Connect to indoor unit

3-way valve diagram

Open position

Spindle

Connect to outdoor unit

Valve core

Needle

Service port cap

Downloaded from AC-Manual.com Manuals

1 2 ... 16 17 18 19 20 21 22

Comments to this Manuals

No comments

Whirlpool AMD 010 Installation Manual Page 21

Comments to this Manuals