Whirlpool WHP1500S User Manual Page 1

Prepared by: WHIRLPOOL CONSUMER CAREHome AppliancesPART NO. 8178687UD-32SERVICE UPDATESECOND HALF—2007

6Water Conductivity SensorWater conductivity sensor has 4 probes. 2 create a loop so that the control knows the connection is made. 2 go in the wate

7Boiler Assembly with Pressure Switch3-11 inches – operatingrange of boilerBoiler Assembly is same as Dual Fuel range boiler. Operating range of boile

8Boiler ComponentsPressure Switch N.O. –closes to open Fill Valve RelayNormally Open pressure switch shown in the wiring diagram. Pressure switch clo

9Boiler ComponentsSteam Boiler Element1300 wattThe 1300 watt Steam boiler element is encased in the Boiler Tank and is serviced with the boiler tank.

10Boiler ComponentsN.C.Thermal Cutout – shuts down Steam BoilerOpens @220˚FCloses @200˚FThe Normally Closed Thermal Cutout, which is mounted to the si

11Boiler ComponentsBoiler Thermistor – @ 240˚ shuts down theSteam Boiler100 ohms @ 77° FAt 240˚the Boiler thermister, which is encased in the boiler t

12KitchenAid Outdoor CookingManufactured by Nexgrill Industries Double Halogen LightingSear BurnerWarming DrawerThe new line of outdoor cooking produc

132007 KitchenAid Outdoor EntertainmentThese Outdoor Entertainment products are serviced with a one year parts and labor warranty.

14PRODUCT UPDATESElectric Freestanding and Slide-In RangesFor any Freestanding and Slide-in electric range that is rated less than 16.5K watts on 240

15SchematicSchematic showing wiring of control.Custom Control Temperature Chart

- ii -FORWARDThe following service update information is provided to make you more knowledgeable about Whirlpool, Roper, KitchenAid, Maytag, Jenn-Air

16LAUNDRYPRODUCT INTRODUCTIONSWhirlpool LaundryA Steam washer and matching dryer will be introduced in October 2007. The washer has a steam generator

17OXI BLEACH DISPENSERDispenser ModicationOxi/Color Safe-• Bleach.Powder recom-• mended, but cus-tomer can use liquid.Timed function is • only for po

18STEAM SYSTEM Steamer Valve Siphon Steamer GeneratorExpansion Board Tub Inlet Overll TubeThe steamer valve is a three coil inlet valve that brings i

19STEAM SYSTEM Heating Element NTC Fuse # 2 Fuse # 1 Thermostat Steel Shield Aluminum Tube with serrationThe generator has an NTC and a thermostat to

20LAUNDRYPRODUCT INTRODUCTIONSWhirlpool LaundryThe Duet Steam Dryer is scheduled for launch in October 2007 and gives the custom-er a solution to remo

21InstallationNew ComponentsThe Steam dryer is installed with the following components and ties the dryer to the washing machine’s cold water supply.

22New ComponentsHigh temp nylon tubing* attaches the inlet valve to the nozzle tting at the rear of the bulkhead.Nozzle FittingHigh temp tubingStanda

23Steam CyclesThe Steam cycles include “Quick Refresh” and “Enhanced Touch Up”A small amount of water is sprayed into the dryer after several minutes

24Component AccessThe inlet valve is attached to the dryer oor and to the nylon tubing with a push con-nect tting.The nozzle tting is held in place

25CABRIO WASHERThe WTW6700T Cabrio washer is scheduled to launch in late September, ’07. It will feature a Spin/Spray rinse as an alternative to the

- iii -TABLE OF CONTENTS COOKING ...

26MAYTAG EPIC WITH OXI/PREWASH OPTIONMFW9800T• The Oxi/PreWash option will add approximately 15 minutes to the main wash cy-• cle.The Oxi/Prewash and

27MAYTAG EPIC ZMHWZ400T and MHWZ600TMaxExtract OptionDuring last 30 seconds of cycle, the spin speed increases 100 rpm for maximum wa-ter extraction.T

28 PRODUCT UPDATESDishwasher/CompactorJENN-AIR / MAYTAG DISHWASHERSWill have a Steam Clean Option.• Can be used with China/Crystal, Normal, Auto and

29Dishwasher Clean Light Dishwasher “Clean” Light Blinks 7 TimesService pointer K8178496The electronic control looks for a temp. rise of 2° - 4° F.If

30KITCHENAID COMPACTORFID Compactor Drawer Start Switch, bending or activated inadvertently.•Factory had been using #6 screws to secure switch and ac

31Two 3196175 #8 screws for actuator blade and/or rubber bumpers. 9872369 Rubber Bumpers780263 Shoulder ScrewsAttaches Foot Pedal to Drawer9871976 Act

32 PRODUCT UPDATESRefrigerationAmana Refrigeration Plant Embraco Service CompressorsEmbraco compressors are currently being substituted for Tecumseh

33Beginning in the 4th quarter of 2007 Embraco Compressors will be used for on all ARP production refrigerators.Mini compressor will reduce energy co

34Jenn Air/Jade SXS’sEvaporator drain pan freeze up Follow all steps outlined in technical Bulletin TDR-0061-BLuxury Built-in Side by SideDrip Pan Fre

35Make sure drain tube is installed as indicated. Service Bulletin TDR-0061-BA kit is currently on test to add addition heat to the drain area.

- iv -TABLE OF CONTENTSREFRIGERATION ... Page 32

36Bottom Mount Freezer Drawer HandleNew door handles and clips are now available for BM freezer drawers.Order replacement handles by model number.Inve

37A new EMZ damper is being used on current production. It will not retrot the Invensys damper.New EMZ DamperBeginning with 4th quarter production, a

38T-Bracket: Easy AssemblyBeginning on 4th quarter production, a new wiring harness, power cord and protective sheath will used on all Amana produced

39Water Line/Reservoir Freeze Up Bottom Mount FreezersWater reservoir or water line freeze ups can occur on some Bottom mount freezers. The cause of

40The power supply on the high voltage control board may fail resulting in the dispenser door continually opening and closing. Eventually the board wi

41New DisplayMaytag 22’ Iceland The display will change and have 2 new pads. On/OFF switch and Humidity Control switch.The verbiage to be used on the

42In the OFF state all cooling functions (compressor, fans, and damper) operation, as well as defrost operations will be turned off. (This will inclu

43this feature. The corresponding LED will turn on indicating that the feature is active (Mullion Heater On). The heater will then cycle with the co

44Service ConsiderationsFor new P# models: A new main control board will be used for service.• Serial plate calls out new personality.• New main cont

45Additional cap tube available in cabinetInsert a 12” length of small diameter rod into the cabinet around the circumference of the cap tube several

1COOKINGPRODUCT INTRODUCTIONS KitchenAid Ultima Built-In Steam Assist Ovens KEBU107SSS (Single) KEBU208SSS (Double) KEHU309SSS (Combina

46Probe against the back of the cabinet and away from the freezer liner Pull the cap tube straight down

47Pull the cap tube out 6 – 8”Remove the drier from the machine compartment and cut in half.

48Use a receptacle to catch the drying agent.Heat and remove the drier inlet tube.

49Heat and remove the cap tubeClean and prepare the heat loop tube and cap tube for drier installation.

50Insert the cap tube into the drier until it contacts the drier screen. Mark the cap tube where it meets the drier outlet tube.

51Pull the cap tube back out ½” to ¾” and braze the connection.Incorrect Cap Tube installation.

52If the cap tube is installed against the screen it will cause a restrictionUse Permagum to seal around the heat exchanger

53KitchenAid Under-Counter Refrigeration ProductsWine CellarBeverage CenterNo Display or Intermittent Display.Some wine coolers and beverage centers

54Separator Connections12vac supply connectorTop thermistor connectorWine cellar has 1 connector, beverage center has 2.Error CodesDisplay shows -4

55IDI Bucket Difcult to RemoveThe new style shaft and coupler can bind when crushing ice• This causes the bucket to become difcult to remove • Cha

2Dual Fan ConvectionDual Fan convection for superior air circulation in the oven. 2600 watt convection element.Steam Cooking Fill ValveConvection Elem

56Central Park RefrigeratorModel GD5VVAXTYThe refrigerator will be shipped with a cap over the connector on the top of the freezer door.This will be a

57Power Supply Board120 VAC in• 14 VDC out• Maximum load • 13-15 Watts continuous• 120 VAC is rectied and regulated to achieve a 14 VDC/13-15 Wa

58FISH LIPS

59Scenario One• The Product is not performing to the customer’s expectations.• Duet washer not cleaning properly.• Customer is not using HE deterge

60Scenario ThreeThe customer has a new microwave oven that the IHSP has not yet been trained • on.It is not programming the way the old one did, nor d

61Scenario FiveThe refrigerator is not cooling properly and needs an electronic control that is on • backorder.The IHSP has to order parts and the cus

62SERVICE POINTER INDEXBRAND & ID# DESCRIPTION DATE ISSUEDWhirlpool 8178621 Kitchen Aid & Whirlpool Slide-In and Freestanding Electric

63Whirlpool8178655 All KitchenAid and Whirlpool Microwave Combination Ovens and KBMC140H***, KBMC147H*** *** ALL COLORS AND ENGINERING DIGITS:

64BRAND & ID# DESCRIPTION DATE ISSUEDMaytag 8178627 MAYTAG FRONT LOAD WASHER AND STACKED LAUNDRY PRODUCTS; Model Numbers: 1/07 Domest

65BRAND & ID# DESCRIPTION DATE ISSUEDMaytag R8178625 Bottom Mount Freezers with Plastic 1/07 Handles; Maytag Models: MFB2262HE*1, MFB2562HE*

3Complete SystemFilterFilter HousingFill Valve w/John Guest FittingsSteam BoilerPressure SwitchWater ConductivitySensorComplete steam system from lte

66TRAINING EVALUATIONPlease use this page as a reminder to provide us with feedback on today’s meeting. Complete the online evaluation form, located o

IN THE UNITED STATES:FOR PRODUCT SPECIFICATIONS AND WARRANTY INFORMATION CALL:FOR TECHNICAL ASSISTANCE WHILE AT THE CUSTOMER’S HOME CALL:THE TECHNICAL

© 2007 WHIRLPOOL CORPORATIONPrinted in the U.S.A.Whirlpool c o r p o r a t i o n Benton Harbor, MichiganPart No. 8178687

4Water Filtration Assembly for Steam –Assist BI OvensHousingFilter5 1/8”2 1/2”16 3/8”3 1/4”The ltration system is required to use the steam function

5Fill Valve w/John Guest ttingsFill Valve shown in wiring diagram. Fill Valve is normally closed. Regulates ow of water into steam boiler. 4 ml/se